行业组件数据 · 2026

HEPA/ULPA过滤器

HEPA(高效空气微粒过滤器)和ULPA(超低穿透率空气过滤器)是风机过滤单元(FFU)中的关键组件,用于洁净室和受控环境。

技术定义与适配语境
典型 HEPA/ULPA过滤器 会按材料、尺寸公差、适配关系和失效风险在 计算机、电子和光学产品制造 中评估。

HEPA(高效空气微粒过滤器)和ULPA(超低穿透率空气过滤器)是风机过滤单元(FFU)中的关键组件,用于洁净室和受控环境。这些过滤器通过由随机排列的纤维(通常由玻璃纤维或合成材料制成)构成的致密滤网捕获微小颗粒。HEPA过滤器必须去除至少99.97%的≥0.3微米颗粒,而ULPA过滤器去除≥99.999%的≥0.12微米颗粒。它们作为FFU中的最终过滤阶段,确保为敏感制造工艺提供超洁净空气。 HEPA/ULPA过滤器基于三种主要机制运行:拦截(颗粒与纤维碰撞)、惯性撞击(较大颗粒无法跟随气流流线而嵌入纤维)和扩散(布朗运动使小颗粒漂移到纤维上)。致密的纤维基质形成曲折路径,捕获颗粒,同时允许洁净空气通过。在FFU中,这些过滤器安装在预过滤器和风机下游,提供单向层流气流,颗粒穿透率极低。

组件规格

定义
HEPA(高效空气微粒过滤器)和ULPA(超低穿透率空气过滤器)是风机过滤单元(FFU)中的关键组件,用于洁净室和受控环境。这些过滤器通过由随机排列的纤维(通常由玻璃纤维或合成材料制成)构成的致密滤网捕获微小颗粒。HEPA过滤器必须去除至少99.97%的≥0.3微米颗粒,而ULPA过滤器去除≥99.999%的≥0.12微米颗粒。它们作为FFU中的最终过滤阶段,确保为敏感制造工艺提供超洁净空气。

HEPA/ULPA过滤器基于三种主要机制运行:拦截(颗粒与纤维碰撞)、惯性撞击(较大颗粒无法跟随气流流线而嵌入纤维)和扩散(布朗运动使小颗粒漂移到纤维上)。致密的纤维基质形成曲折路径,捕获颗粒,同时允许洁净空气通过。在FFU中,这些过滤器安装在预过滤器和风机下游,提供单向层流气流,颗粒穿透率极低。
工作原理
HEPA/ULPA filters operate on three primary mechanisms: interception (particles collide with fibers), impaction (larger particles cannot follow air streamlines and embed in fibers), and diffusion (Brownian motion causes small particles to drift into fibers). The dense fiber matrix creates a tortuous path that traps particles while allowing clean air to pass through. In FFUs, these filters are mounted downstream of pre-filters and fans, providing unidirectional laminar airflow with minimal particle penetration.
材料
滤材:硼硅酸盐玻璃微纤维或合成材料(如聚丙烯、PTFE)。框架:铝、镀锌钢或不锈钢。密封胶:聚氨酯、硅酮或环氧树脂垫圈。隔板:铝箔、波纹介质或热熔胶。
Dimensions
Standard: 610×610×69 mm, 305×610×69 mm
Efficiency
HEPA: ≥99.97% @ 0.3μm; ULPA: ≥99.999% @ 0.12μm
Fire Rating
UL 900 Class 1 or Class 2
Pressure Drop
Initial: 100-250 Pa; Final: 2-3× initial
Humidity Range
0-100% RH (non-condensing)
Airflow Capacity
0.3-0.5 m/s face velocity
Temperature Range
-40°C to 80°C
标准
ISO 29463ISO 14644EN 1822IEST-RP-CC001

行业分类与别名

HEPA/ULPA过滤器 的常用贸易名称、技术标识和检索关键词。

上级产品

该组件会出现在以下整机或工业产品中。

FMEA · 风险与缓解

诱因 → 失效模式 → 工程缓解

Improper installation or damaged gaskets->Air bypass around filter, reducing efficiency->Use proper sealing techniques, conduct integrity testing (e.g., DOP/PAO test) after installation
Excessive particulate loading without pre-filtration->Increased pressure drop, reduced airflow, potential media rupture->Install adequate pre-filters (MERV 8-13), monitor differential pressure regularly
High humidity or condensation->Media degradation, microbial growth, reduced efficiency->Maintain environmental controls, use hydrophobic media if needed, ensure proper drainage

工业生态与工程逻辑

0
Filter bypass due to improper sealing
1
Media damage from excessive pressure or moisture
2
Biological growth in humid environments
3
Fire hazard if non-rated filters used in critical areas
4
Performance degradation from clogging

合规与检测

tolerance
Filter efficiency must be within ±5% of rated value; frame dimensions within ±1.5mm; pressure drop within ±10% of specified initial value
test method
Efficiency testing per ISO 29463 or EN 1822 using particle counters or photometers; integrity testing via DOP/PAO aerosol scan; pressure drop measurement at rated airflow

制造该组件的工厂

来自 CNFX 组件能力表的相关制造商资料。

制造商列表用于前期研究和供应商能力理解,不代表认证、排名或交易担保。

采购评估维度

不是客户评论,也不是实时热度。以下维度用于前期 RFQ 准备和供应商评估。

技术文档
4/5
制造能力
4/5
可检验性
5/5
供应商透明度
3/5

这些分值是采购评估维度示例,不代表真实客户评分、具体国家买家反馈或实时询盘。

相关组件

常见问题

What is the difference between HEPA and ULPA filters?

HEPA filters capture ≥99.97% of particles ≥0.3 microns, while ULPA filters capture ≥99.999% of particles ≥0.12 microns. ULPA filters provide higher efficiency for smaller particles, used in stricter cleanroom classes (ISO 1-3).

How often should HEPA/ULPA filters in FFUs be replaced?

Replacement depends on operating hours, particle load, and pressure drop. Typically, every 3-5 years with proper pre-filtration. Monitor pressure drop; replace when it reaches 2-3 times the initial value or if integrity tests fail.

Can HEPA/ULPA filters be cleaned and reused?

No, these are disposable filters. Cleaning damages the fiber matrix and compromises efficiency. They must be replaced when performance degrades.

我可以直接联系工厂吗?

CNFX 是开放目录,不是交易平台或采购代理。工厂资料和表单用于帮助你准备直接沟通。

CNFX Industrial Component Index · 计算机、电子和光学产品制造

数据基础

CNFX 制造商资料、技术分类、公开产品信息和持续合理性检查。

初步技术归类
本页用于结构化准备研究、RFQ 和供应商评估,不替代买方自己的供应商资质审查、标准核验和技术批准。

请求制造能力信息: HEPA/ULPA过滤器

说明目标数量、应用场景、交期和关键技术要求,用于准备 RFQ 或供应商评估。

谢谢,信息已发送。
提交失败,请稍后重试;如果反复失败,请直接发邮件到 contact@cnfx.com。

需要制造 HEPA/ULPA过滤器?

对比具备该组件加工或装配能力的制造商资料。

创建制造商档案 联系我们
上一个组件
Gamma LUT 存储器
下一个组件
I/O 组
URN:CNFX:ME:UNIT:HEPA_ULPA_FILTER